|
| Vehicles, Mobilizers etc.
407L Loading System
The purpose of the 407L loading system is to permit loading and unloading of most types of pallets or shelters by three people, operating mechanical hoists in the absence of any powered equipment. The size of the pallet shelter is limited only by the dimensions of the truck body. The components used in this system are mechanical devices that use levers and pulleys. Maximum mechanical advantages, through the use of three hoists, four snatchblocks, and cables, permit pulling, lifting, and lowering with minimum effort. The maximum load capacity for the 407L loading system is 10,000 pounds. The loading operation will require three people, one to operate each hoist and one to drive the truck. It is also advisable for you to have a fourth person stand near the tailgate to observe that the load is being lifted straight and to prevent any misalignment of the load or pallet between the sides of the truck body.
The system components were designed for installation on an M-35 truck or equivalent for lifting and lowering most types of pallet/shelters on and off the truck. Two of the hoists are used in loading and three are used in unloading. The only interface that is necessary between the loading system and the pallet/shelter is that the pallet or shelter must have two towing eyes at the bottom corners. The exact location of the towing eyes is not critical. The system is not restricted to any number, height or configuration of skid types. The hoists, wire rope, wrecking bar, and snatch blocks are commercial hoisting equipment and are not limited to the 407L loading system. You may therefore use them if this is not in conflict with area SOPs for any other hoisting, positioning, or moving task that is within the capacities specified on the equipment.
Manufacturer: Benet R&E Laboratories,
Watervliet Arsenal
Photos
A1B Fuel Trailer
A/M32U-17 Mobilizer
Notes: Consists of a front and rear dolly which are coupled together during transport or storage. They are equipped with a towing bar and steering mechanism for the front dolly. When in use, the dollies are uncoupled and attached to opposite ends of a shelter which is then easily transportable. Maximum Load: U-17 - 8.5 tons
Forklift
Manufacturer: (GM?)
Photo
Forklift
Manufacturer: Terex
Photo
M-35A2 Truck, Cargo, 2½ Ton, 6x6
General information
2 1/2 Ton, 6x6, W/Winch
Crew/Cab Capacity: 2
Vehicle data
Replaces: M35A1
Life Expectancy: 15 Years
Payload: 10,350 lb, Off Road: 7,000 lb
Towed Load Allowance: 6,000 lb
Characteristics
Engine: LD465-1C no turbo; LDT-465-1C whistler turbo; LDT-465-1D non whistler turbocharger;
Horsepower: 140 bhp @ 2,600 rpm
Transmission: Manual; 5 fwd, 1 rev
Electrical System: 24 Volt
Tires: 9:00 x 20, 8-ply
Brakes: Air over hydraulic
Fuel Type: multi fuel, diesel, gasoline and JP (required oil to be added to fuel if using gas or JP)
Blackout Lights: Yes
Performance data
Fording:
W/Kit: 72 in
WO/Kit: 30 in
Approach Angle: 40 Degrees
Maximum Speed: 58 mph
Fuel Capacity: 50 gal
Range: 350 miles
Equipment options
Kits: Personnel Heater, Winterization,
Fording, Electric or Air
Brake, Troop Seat, Cargo Body Closure (Arctic)
Winch: Yes
Shipping data
Weight: 13,700 lb
Ground Clearance: 10 15/16 in
Manufacturer: Kaiser-Jeep and A.M. General
Photos
M36A2 Truck, cargo, 2 ½ Ton
General information
2 ½ Ton, 6x6, XLWB, W/Winch
Crew/Cab Capacity: 2
Characteristics
Engine: LDS-465 multifuel diesel engine
Horsepower: 140 bhp @ 2,600 rpm
Transmission: Manual; 5 Fwd, 1 Rev
Electrical System: 24 Volt
Tires: 9:00 x 20, 8-ply
Brakes: Air over hydraulic
Blackout Lights: Yes
Performance data
Fording:
W/Kit: 72 in
WO/Kit: 30 in
Approach Angle: 40 Degrees
Vehicle data
Replaces: M36
Life Expectancy: 15 Years
Payload: 5,000 lb
Towed Load Allowance 6,000 lb
Equipment options
Kits: Personnel Heater, Winterization,
Fording, Electric or Air Brakes, “A” Frame
Winch: Yes
Shipping data
Weight: 15,800 lb
Ground Clearance: 10 15/16 in
Notes: Extra-long wheelbase, drop side
Photos
M-37 Truck Cargo, 3/4 ton
Manufacturer: T245 Dodge
Engine: “L” Head, Inline 6 cylinder 230 cubic inches
Horsepower: 92 horsepower
Transmission: 4 speed manual, Synchro-Shift in 3rd and 4th gear
Electrical System: 24 volt
Fuel Type: gasoline
Fuel Capacity: 24 gallons
Tire Size: 9.00 x 16 - 8 ply non-directional military
Highway Speed: 55 mph (90 km/h), Range: 150 mi (240 km), 6 mpg US (39 L/100 km)
Winch: PTO operated, 7500 lb
Notes:
M-49 Truck, Tank, Fuel Servicing, 6x6
General information
2 1/2 Ton 6x6, Fuel Servicing, W/Winch
Characteristics
Engine: Multifuel
Horsepower: 140 bhp @ 2,600 rpm
Transmission: Manual; 5 Fwd, 1 Rev
Electrical System: 24 Volt
Tires: 9:00 x 20, 8-ply
Brakes: Air over hydraulic
Blackout Lights: Yes
Performance data
Fording:
W/Kit: 72 in
WO/Kit: 30 in
Approach Angle: 40 Degrees
Maximum Speed: 58 mph
Range: 350 miles
Vehicle data
Replaces: M49A1C
Life Expectancy: 15 Years
Payload: 7,200 lb
Towed Load Allowance: 6,000 lb
Equipment options
Kits: Personnel Heater, Winterization, Fording, Electric or Air Brakes
Winch: Yes
Shipping data
Weight: 15,048 lb
Ground Clearance: 10 15/16 in
Photos
M-50 Truck, Tanker
General information
2 1/2 Ton, 6x6, Water, 1000 Gal, W/Winch, W/E
Crew/Cab Capacity: 2
Characteristics
Horsepower: 140 bhp @ 2,600 rpm
Transmission: Manual; 5 Fwd, 1 Rev
Electrical System: 24 Volt
Tires: 9:00 x 20, 8-ply
Brakes: Air over hydraulic
Blackout Lights: Yes
Performance data
Fording:
W/Kit: 72 in
WO/Kit: 30 in
Approach Angle: 40 Degrees
Vehicle data
Replaced By: M50A3
Life Expectancy: 15 Years
Payload: 400 gal
Towed Load Allowance: 6,000 lb
Equipment options
Kits: Fording, Winterization, Personnel Heater
Winch: Yes
Shipping data
Weight: 14,600 lb
Ground Clearance: 10 15/16 in
Photos
M-101 Trailer, Cargo
General information
3/4-Ton, 2 Wheel, W/E
Characteristics
Electrical System: 24 Volt
Tires: 9:00 x 16, 8-ply
Brakes: Mechanical, parking brake only
Blackout Lights: Yes
Performance data
Fording:
W/Kit: None
WO/Kit: 30 in
Departure Angle: 33 Degrees
Vehicle data
Replaced By: M101A1
Life Expectancy: 30 Years
Payload: Empty -1,340 lb
Cross Country -2,840 lb
Highway -3,590 lb
Gross Vehicle Weight: 2,840 lb
Equipment options
Kits: Installation Stabilizer, Rear, Tarpaulin
Shipping data
Weight: 1,340 lb
Shipping Volume: 520 cu ft
Cross Country: 213 cu ft
Ground Clearance: 14 in
Photos
M-105 Trailer, Cargo
General information
1 1/2-Ton, 2 Wheel
Characteristics
Electrical System: 24 Volt
Tires: 9:00 x 20, 8-ply NDCC
Brakes: Air over hydraulic
Blackout Lights: Yes
Vehicle data
Replaced By: M105A2
Life Expectancy: 20 Years
Payload: 3,000 lb
Gross Vehicle Weight: 5,750 lb
Equipment options
Kits: Bow and Tarp
Performance data
Fording:
W/Kit
WO/Kit: Submersible to top of Chassis
Shipping data
Weight: 2,750 lb
Ground Clearance: 16 1/2 in
Lunette Height: 29 3/4 in to 33 3/4 in
Photos
M-107 Trailer tank
General information
1 l/2-Ton, 2 Wheel, 400 Gallons
Characteristics
Electrical System: 24 Volt
Tires: 9:00 x 20, 8-ply
Brakes: Air over hydraulic
Blackout Lights: Yes
Performance data
Fording:
W/Kit:
WO/Kit: Completely submersible (floats)
Approach Angle: 32 Degrees
Vehicle data
Replaced By: M149A2
Life Expectancy: 20 Years
Payload: 3,000 lb
Gross Vehicle Weight: 5,380 lb
Equipment options
Kits:
Shipping data
Weight: 2,380 lb
Ground Clearance: 16 1/8 in
Lunette Height: 30 1/4 in
Photos
M-149 Trailer, Potable Water Tank
General information
1 l/2-Ton, Water, 2 Wheel, 400 Gal, W/E
Characteristics
Electrical System: 24 Volt
Tires: 9:00 x 20, 8-ply
Brakes: Air over hydraulic
Blackout Lights: Yes
Vehicle data
Replaced By: M149A2
Life Expectancy: 12 Years
Payload: 3,335 lb
Gross Vehicle Weight: 5,835 lb
Performance data
Fording:
W/Kit:
WO/Kit: Floats
Approach Angle: 37 Degrees
Equipment options
Kits:
Shipping data
Weight: 2,500 lb
Ground Clearance: 17 in
Lunette Height: 30 1/4 in
Photos
M-151 Military Utility Tactical Truck (Jeep)
General Information
1/4-Ton, 4x4
Characteristics
Engine: 4-cylinder, 141.5 cubic inch
Horsepower: Pre-emission -71 bhp @
4,000 rpm; Emission -65 bhp @ 4,000 rpm
Transmission: Manual; 4 Fwd, 1 Rev
Electrical System: 24 Volt
Tires: 7:00 x 16, ply-4 (6 ply rating)
Brakes: Hydraulic
Blackout Lights: Yes
Vehicle Data
Payload: 800 lb (Including Crew)
Towed Load Allowance: Trailer W/Brakes 1,170 lb
Shipping Data
Curb Weight, Fully Equipped Less Payload and
Crew:
Front Axle -1,362 lb
Rear Axle -1,078 lb
Total -2,440 lb
Gross Weight, Fully Equipped With Payload and Crew:
Front Axle -1,762 lb
Rear Axle- 1,478 lb
Total -3,240 lb
Wheelbase: 85 inch Length
Production: More than 100,000 (1959 - 1982)
Successor: AM General HMMWV
Manufacturer: Ford
Photos
M-715 Truck, Cargo 1¼ Ton
Length: 220 inches
Width: 85 inches
Weight: 5,180 pounds
Height: 95 inches
Engine: Inline 6-cyl, 230ci
Horsepower: 132hp
Transmission: four-speed, synchronized
Electrical system: 24 volt/12 volt
Fuel type: gas
Fuel capacity: 28 gallons
Top Speed: 55mph
Tires: 9.00 x 16 8-ply
Manufacturer: Kaiser
Notes: 4X4
Photos
M-720 Dolly Set, Lift, Transportable Shelter
General information
The M-720 mobilizer can be used when the equipment is to be moved on improved or unimproved road surfaces in flat, unobstructed terrain, such as open deserts or plains. The M—720 mobilizer is a 6000-pound load mobilizer which separates into two dolly-wheel sets, the M-721 and the M-722, for attachment to the ends of an equipment shelter or equipment pallet. M-720 mobilizers are attached to the equipment shelter by raising each mobilizer set with a 5-foot lever until the bolt holes in the mobilizer are aligned with the bolt holes in the equipment shelter.
After the dolly wheels are attached, the hydraulic jack system lifts the equipment shelter or pallet to the road position. The mobilizer is connected into the electrical air brake systems of the towing truck. An emergency brake system on the mobilizer automatically locks the brakes on all four wheels when air pressure from the truck is lost. A manual brake system provides mechanical braking to the rear wheels only. Inflate the airbags on an attached M-720 mobilizer set until the white band on the lower part of each shock absorber is visible.
Characteristics equipment options
Electrical System: 12 Volt, 24 Volt
Tires: 7:00 x 16
Brakes: Air over hydraulic
Blackout Lights: Yes
Performance data
Fording: Submersible running gear
Approach Angle: 60 Degrees
Departure Angle: 90 Degrees
Vehicle data
Payload: 6,000 lb
Life Expectancy: 25 Years
Shipping data
Width: 96 inches
Height: 44 inches
Length: 93 inches)
Weight: 1,770 lb
Ground Clearance: 14 in
Lunette Height: 31 in
Notes: Consists of a front and rear dolly which are coupled together during transport or storage. They are equipped with a towing bar and steering mechanism for the front dolly. When in use, the dollies are uncoupled and attached to opposite ends of a shelter which is then easily transportable. Designed for handling and transport of S-280 style tactical shelters
Photos
M-725 Truck, Ambulance
See M-715
M-816 Medium Wrecker
Description
Years Produced: 1970-1981
Length: 356 1/4 in
Width: 98 in
Height: 106 in (minimum)
Weight (curb): 36,129 lbs
Weight Capacity:
payload-7000
Towed-20,000
Engine: Cummins NHC-250 normally aspirated Horsepower:240@2100 rpm
Transmission: Spicer 6352 5 speed O/D
Transfer Case: Timken T-138
Axles: Rockwell
Differentials: Rockwell 6.44 to1 ratio
Electrical System: 24 volt waterproof
Heating & Cooling: water cooled
Brakes: hyd/air assisted
Fuel Type: diesel
Fuel Capacity: 133 gal
Fuel Range: 585 miles
Manufactured by: AM General, Kaiser/Jeep
Photos
M-832 Dolly Set, Lift, Transportable Shelter
General information
5 l/4-Ton
Characteristics
Electrical System: 24 Volt
Tires: 4, 9:00 x 20
Brakes: Air over hydraulic
Suspension: Air Bags
Blackout Lights: Yes
Performance data
Speed: Highway 50 mph; Off-Road 25 mph
Fording: Submersible
Equipment options
Kits:
Vehicle data
Replaces: M689
Life Expectancy: 25 Years
Payload: 10,500 lb
Shipping data
Width: 96 in
Height: 54.5 inches
Length: with Towbar 184 inches
Weight: 3,700 lb
Ground Clearance: 17 in
Lunette Height: 31 in
Departure Angle: 90 Degrees
Notes: Consists of a front and rear dolly which are coupled together during transport or storage. They are equipped with a towing bar and steering mechanism for the front dolly. When in use, the dollies are uncoupled and attached to opposite ends of a shelter which is then easily transportable.
Photos
M-880/885 Truck, ¾ Ton
General information
1 1/4 Ton, 4x2
Crew/Cab Capacity: 3
Characteristics
Horsepower: 150 bhp @ 4,000 rpm
Transmission: Automatic
Electrical System: 12 Volt
Winch: No
Tires: 9:50 R 16.5 LT 4 R-D Custom Flexsteel XG
Fuel Tank: 20 Gallons
Blackout Lights: Blackout light kit Optional
Vehicle data
Replaces: M37/M715
Life Expectancy: 7 Years
Payload: 2,500 lb
Towed Load Allowance: 3,000 lb
Equipment options
Kits: Blackout Lights, Troop Seat,
Cargo Box, Personnel Heater
Shipping data
Weight: 4,217 lb
Ground Clearance: 8 1/2 in
Manufacturer: Dodge
Notes:
Photos
M-923 Truck, cargo, 5-ton, 6X6,
Notes: Dropside, diesel engine
M-928 Truck, Cargo
General information
5 Ton, 6x6, XLWB, W/Winch, W/E
Crew/Cab Capacity: 3
Characteristics
Horsepower: 240 bhp @ 2,100 rpm
Transmission: Automatic; 5 Fwd, 1 Rev
Electrical System: 24 Volt
Tires: 11:00 x 20, 12-ply
Brakes: Air
Blackout Lights: Yes
Performance data
Fording:
W/Kit: 78 in
WO/Kit: 30 in
Approach Angle: 31 Degrees
Maximum Speed: 54 mph
Range: 300 miles
Vehicle data
Replaces: M814
Life Expectancy: 20 Years
Payload: 10,000 lb
Towed Load Allowance: 15,000 lb
Equipment options
Kits: 100 Amp Alternator, Radiator and Hood Cover, Engine Coolant Heater, Fuel Burning Heater, Chemical Alarm, Deep Water Fording, Gun Ring Mounting, Machine Gun Adapter, M13 Decontamination, Bow and Tarp, “A” Frame, Swingfire Heater
Winch: Yes
Shipping data
Weight: 25,588 lb
Ground Clearance: 10 1/2 in
Photos
M-936 TRUCK, MEDIUM WRECKER
General information
5-Ton, 6x6, W/Winch
Crew/Cab Capacity: 3
Characteristics
Engine: Diesel, 6 cyl.
Horsepower: 240 bhp @ 2,100 rpm
Transmission: Automatic; 5 Fwd, 1 Rev
Electrical System: 24 Volt
Tires: 11:00 x 20, 12-pIy
Brakes: Air
Blackout Lights: Yes
Performance data
Fording:
W/Kit: 78 in
WO/Kit: 30 in
Approach Angle: 31 Degrees
Maximum Speed: 54 mph
Range: 400 miles
Vehicle data
Replaces: M543, M816
Life Expectancy: 20 Years
Payload: 7,000 lb
Towed Load Allowance: 20,000 lb
Equipment options
Kits: 100 Amp Alternator, Radiator and Hood Cover, Engine Coolant Heater, Chemical Alarm, Deep Water Fording, Gun Ring Mounting, Machine Gun Adapter, “A” Frame, M13 decontamination, Swingfire Heater
Winch: Yes
Shipping data
Weight: 36,129 lb
Ground Clearance: 10 1/2 in
Photos
M-1008 Truck, Pickup
General information
1 1/4-Ton, 4x4
Crew/Cab Capacity: 3
Characteristics
Horsepower: 135 hp @ 3,600 rpm
Transmission: 3-Speed Automatic
Electrical System: 28 Volt, 100 Amp
Tires: LT 235/85R-16E, Steel Belted Radials
Brakes: Front Disc-Rear Drum,
Silicone Fluid
Blackout Lights: Yes
Performance data
Fording: WO/Kit: 20 in
Approach Angle: 42 Degrees, 20 Minutes
Vehicle data
Replaces: M880, M881, M890, M891
Life Expectancy: 7 Years
Payload: 2,900 lb
Towed Load Allowance: 3,000 lb
Equipment options
Kits: Coust, Arctic, Troop Seat
Winch:
Shipping data
Curb Weight: 5,900 lb
Ground Clearance: 7.8 in
Manufacturer: Chevrolet
Photos
M-1009 Tactical Utility, 3/4 ton 4X4
General Information
3/4-Ton, 4x4
Replaces/Replaced By: M151 and M101
Crew/Cab Capacity: 4
Characteristics
Engine: V8, 6.2L (379 ci), fuel injected diesel
Horsepower: 135 bhp @ 3,600 rpm
Transmission: TH400, 3 speed, automatic
Electrical System: 24 Volt
Tires: 10 R 15 LT (Load Range C)
Fuel Tank: 27 gallons
Brakes: Front Disc-Rear Drum, Silicone Fluid
Blackout Lights: Yes
Fuel Capacity: 27 gal
Performance Data
Fording:
W/Kit:N/A;
WO/Kit: 16 to 20-in
Approach Angle: 39 Degrees, 48 Minutes
Shipping Data
Weight: Curb -5,280 lb
Ground Clearance: 9.6 in
Maximum Speed: 55 mph
Vehicle Data
Replaces/Replaced By: M151 and M101
Life Expectancy: 7 Years
Payload: 1,200-1,500 lb
Towed Load Allowance: 3,000 lb
Manufacturer: General Motors
Notes: Modified Blazer
Photos
M-1022A1 Dolly Set, Lift, Transportable Shelter, 7 1/2-ton
Weight: M-1022, 5,580 pounds; M-1022A1 6,150 pounds
Lift Capacity: M-1022 15,000 pounds; M-1022A1 20,000 pounds @ 50 mph
Length: Maximum 36 feet
Width: 96 inches
Engine: Diesel, 6.2 hp
Tires: 12R / 22.5
Brakes: Air (from tow vehicle)
Suspension: Air Bag
Notes: Diesel powered hydraulic system for ease of connection and lift; Wheels lift off ground for changing of tires without jack;
Manufacturer: Gabrial of Canada
M1078 2.5 ton Truck
M-1083 or M1083A1 Medium, Tactical Vehicle, 5 ton
Specifications: 6x6 (full-time) with locking interaxle differential
Engine: Diesel, 290 hp; Caterpillar, Diesel, 6-Cylinder 6.6 L, turbocharged and aftercooled
Transmission: Automatic; 7 speeds, automatic/select
Electrical: 12/24 V
Speed: 58 mph
Range: 300
Payload: 10,000 lb
Fuel: Diesel, DF-2, JP-4, JP-8,
Notes: Cab-over-engine
Photos
M-1097 High Mobility Multi-purpose Wheeled Vehicle (HMMWV)
General Information
Characteristics:
Engine:
Type: 6.5 liter diesel, naturally-aspirated, liquid-cooled
Cylinders: 8(V)
Brake horsepower: 160 horsepower @ 3400 rpm
Transmission: Turbo Hydra-Matic 3L80, three-speed automatic
Range: 275 mi (442 km)
Max speed: 70 mph
Vehicle Data
Length: 180 inches
Height: 69 inches
Width: 85 inches
Ground Clearance: 16 inches
Weight: 5,600 lbs.
Manufacturer: General Motors
Notes: Higher payload capacity configuration of the HMMWV; Replacement for the M151 series jeeps
Photos
|
